Product ID:N-7318 LOW VOC GOLD SI. ALKYD
MSDS Date:06/09/1999
FSC:8010
NIIN:01-468-3267
Status Code:A
MSDS Number: CLQZQ

NILES CHEMICAL PAINT

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856

Info Phone: 616-683-3377/219-236-5856

Preparer: ERNEST CARTER

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

HIGH SOLIDS SILICONE

PARACHLOROBENOTRIFLOURIDE

CAS: 98-56-6

#100 SOLVENT

CAS: 64742-95-6

RTECS: WF3400000

COBALT COMPOUNDS

CAS: 7440-48-4

RTECS: GF8750000

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.02 MG/M3

ACRYLIC RESIN

Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Explanation of Carcinogenicity:COBALT IS LISTED AS A GROUP 2B
CARCINOGEN.
Effects of Overexposure:EYES: SEVERE IRRITATION, LACRIMATION, REDNESS,
BLURRED VISION. SKIN: REDNESS AND IRRITATION, DEFATTING OF THE SKIN
LEADING TO DERMATITIS. BREATHING: NASAL AND RESPIRATORY IRRITATION,
CNS DEPRESSION (D IZZINESS, DROWSINESS, WEAKNESS, FATIGUE,
CONFUSION) NAUSEA. SWALLOWING: GASTROINTESTINAL IRRITATION,
ABDOMINAL PAIN, NAUSEA, VOMITING, DIARRHEA. CHRONIC EFFECTS OF
OVEREXPOSURE: LIVER, KIDNEY, CNS. PR OLONGED EXPOSURE TO SOLVENTS
MAY CAUSE CHRONIC HEALTH EFFECTS. TARGET ORGANS: LIVER, KIDNEYS,
CNS, LUNGS, SKIN, EYES, RESPIRATORY SYSTEM.

First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AT ONCE.GET MEDICAL
ATTENTION. SKIN CONTACT: IMMEDIATELY FLUSH SKIN WITH PLENTY OF
WATER.GET MEDICAL ATTENTION.EYE CONTACT: IMMEDIATELY FLUSH EYES
WITH LARGE AMOUN TS OF WATER FOR AT LEAST 15 MINUTES.OCCASIONALLY
LIFTING UPPER AND LOWER LIDS.GET MEDICAL ATTENTION.SWALLOWING:
DRINK 1 RO 2 GLASSES OF WATER. DO NOT INDUCE VOMITING. CONSULT A
PHYSICIAN OR POISON CON TROL CENTER IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=37.8C, 100.F
Lower Limits:0.8%
Upper Limits:12.0%
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN POSITIVE PRESSURE MODE AND FULL
PROTECTIVE CLOTHING. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD UP AND POSSIBLE AUTO IGNITION OR EXPLOSION
WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG THE GROUND TO AN IGNITION
SOURCE. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT, AND OPEN
FLAME, CLOSED CONTAINERS M AY EXPLODE WHEN EXPOSED TO EXTREME
HEAT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. MINIMIZE THE
BREATHING OF VAPORS AND AVOID SKIN CONTACT. ABSORB WITH AN
INERT MATERIAL SUCH AS CLAY, SOIL, OR A COMMERCIALLY AVAILABLE
ABSORBENT. FOR LARGE SPILLS: RECLAIM INTO RECOVERY OR SALVAGE
DRUMS OR TANK TRUCK FOR DISPOSAL.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE.AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING
MAY SPILL CONTAINER.

Respiratory Protection:WEAR AN APPROPRIATE (TYPE TC-23C-75) PROPERLY
FILLTED HALF-MASK OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING
AND AFTER APPLICATION UNLESS AIR MONITORING DEMONTRATES VAPOR/MIST
LEVELS ARE BELOW APP LICABLE LIMITS. FOLLOW RESPIRATOR
MANUFACTURER'S DIRECTIONS FOR USE.
Ventilation:SUFFICIENT VENTILATION IN VOLUME AND PATTERN SHOULD BE
PROVIDED TO KEEP THE AIR CONCENTRATION BELOW CURRENT APPLICABLE
OSHA PERMISSIBLE EXPOSURE LIMIT.
Protective Gloves:WEAR CHEMICAL RESISTANT (NITRILE OR VITON) GLOVES
Eye Protection:WEAR CHEMICAL GOGGLES, SAFETY GLASSES, OR FACE SHIELDS.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM.
Supplemental Safety and Health

Boiling Pt:=203.3C, 398.F
Vapor Density:HEAVIER
Spec Gravity:1.344
VOC Grams/Liter:1.51
Viscosity:54-67 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:57.40
Corrosion Rate:MINIEAL

Stability Indicator/Materials to Avoid:YES
OXIDIZERS, STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS.

Toxicological Information:INGESTION: LOW ACUTE ORAL TOXICITY: LD50
(ORAL, RAT) IS 2,550 MG/KG. SKIN/DERMAL: LOW ACUTE DERMAL TOXICITY:
LD50 IN RABBITS > 2,000 MG/KG. INHALATION: LOW ACUTE INHALATION
TOXICITY: LC50 IN RATS IS GREATER THAN 2 MG/L (OR G/M3).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:PHOTOTOXICITY: BORON CAN BE HARMFUL TO SOME SENSITIVE PLANTS
(E.G. GRASS AND ORNAMENTALS) IN HIGH QUANTITIES. ALGAL TOXICITY:
96-HR EC10 = 24 MG B/L. INTERBERATE TOXICITY: DAPHNIDS, DAPHNIA
MAGNA STRA US 24-HR EC50 = 242 MG B/L. FISH TOXICITY: DAB, LIMANDA
LIMANDA 96-HR LC50 = 74 MG B/L. FRESHWATER: RAINBOW TROUT, S.
GAIRDNERI (EMBRYO-LARVAL STAGE) 24-DAY LC50 = 88 MG B/L 32-DAY LC50
= 54 MG B/L. G OLDFISH: 7-DAY LC50 65 MG B/L 3-DAY LC50 = 71 MG
B/L.

Transport Information:DOT HAZARDOUS CLASSIFICATION: DISODIUM OCTABORATE
TETRAHYDRATE (TIM-BOR) IS NOT REGULATED BY THE U.S. DEPARTMENT OF
TRANSPORTATION.

SARA Title III Information:THIS PRODUCT DOES NOT CONTAIN INGREDIENTS
LISTED IN APPENDIX A AND B AS AN EXTREMELY HAZARDOUS SUBSTANCE.
OUR HAZARD EVALUATION HAS FOUND THIS PRODUCT TO BE HAZARDOUS . THE
PRODUCT SHOULD BE REPORTED UNDER THE FOLLOWING EPA HAZARD
CATEGORIES: [X] IMMEDIATE (ACUTE) HEALTH HAZARD. [X] DELAYED
(CHRONIC) HEALTH HAZARD.
State Regulatory Information: